TY - JOUR ID - TI - Assessment Mixing and Compaction Temperatures for Modified HMA Using Superpave High Shear Viscosity Methods تقييم درجات الحرارة خلط ودمك الأسفلت المعدل باستخدام طريقتي السوبربيف واللزوجة العالية القص AU - Alaa Hussein Abed علاء حسين عبد AU - Ali Hwaidi Nasser علي هويدي ناصر PY - 2018 VL - 21 IS - 4 SP - 516 EP - 522 JO - Al-Nahrain Journal for Engineering Sciences مجلة النهرين للعلوم الهندسية SN - 25219154 25219162 AB - The objective of this study is determining the mixing and compaction temperature of the modified asphalt mixture. Results of binder testsshowed that the addition of 3% SBS to control asphalt (PG 64-16) would achieve the desired performance level (PG 76-16) a performance grade that fits our climate with traffic loads. When using5% SBS the performance grade of binder increased three grades (PG 82-16) and when increasing SBS content to 8% the performance grade increased four grades (PG 88-16). At shear rate of 500 (s-1),the modified asphalt viscosity can be obtained at different temperatures and the viscosity temperature curve can be achieved. As a result, the mixing and compaction temperature of modifiedasphalt can be determined to reach 0.17 ± 0.02 Pa.sand 0.28 ± 0.03 Pa.s for mixing and compaction, respectively. It is noted that SBS modified reached a viscosity of 3 Pa.s when 8 % additive. Additivecontents above these values may not be suitable for good workability and pump ability according to Superpave specifications. While addition of 5% SBS with control asphalt, more than 3.7times at135°C Increase the viscosity. Marshall Stability test indicated that the strength for the SBS specimens increases as compared to theconventional specimens. An increase of about 39%, 74%, 102%, was observed with 3% SBS 5%SBS 8%SBS modified binders, respectively.The Marshall test results for 8%SBS binders required compaction temperatures above 175°C need to keep up quality of HMA item whilelimiting natural effect amid development, these proposals are unsatisfactory Modified mixtures the 5% SBS modification was determined to be the maximum useful content. The Superpave methodto estimate mixing and compaction temperatures show are not practical for use with modified binders. Also, it is observed that good agreement values between the average Marshall compactiontemperature and the High Shear Viscosity Method (HSRV) and lower than Superpave methods Where the decline ranges from 15 ºC to 17 ºC

الهدف من هذه الدراسة هو تحديد درجة حرارة الخلط والدمك للخلطة الإسفلتية الساخنة للاسفلت المحسن. وأظهرت نتائج اختبارات الاسفلتالمحسن أن إضافة ٪ 3الستايرين بيوتادين ستايرين للاسفلت الغير محسن ( )PG 64-16حققت مستوى الأداء المطلوب (.)PG 76-16ايدرجة أداء تناسب مناخنا مع الأحمال المرورية. عند استخدام ٪5الستايرين بيوتادين ستايرين زادت درجة أداء الاسفلت ثلاث درجات (PG )82-16وعند زيادة المحتوى إلى ٪8زادت أربع درجات ( .)PG 88-16عند معدل القص ، )s-1( 555يمكن الحصول على لزوجةالإسفلت المحسن عند درجات حرارة مختلفة ويمكن تحقيق منحنى درجة الحرارة اللزوجة. نتيجة لذلك ، يمكن تحديد درجة حرارة الخلطوالضغط من الأسفلت المعدل لتصل إلى 5.50 ± 5..0باسكال و 5.53 ± 5.08باسكال للخلط والضغط ، على التوالي.لوحظ ان لزوجة الاسفلت المعدل ببوليمر (ستايرين بيوتادين ستايرين - )SBSتصل الى درجة 3باسكال في الثانية عند إضافة %8منالبوليمر. عند زيادة نسبة المضاف اكثر من هذه القيمة تؤدي الى مشاكل في قابلية التشغيل والضخ حسب مواصفات الاسفلت عالي الأداء. تزدادقيمة الثبوتية لماشال بمقدار 3.7عند إضافة %5من البوليمر. وتزداد قيمة فحص المقاومة الغير مباشر بمقدار %.50 ، %07 ، %33عند إضافة %8 ، %5 ، % 3على التوالي. عند إضافة %8من البوليمر الى الاسفلت يتطلب زيادة درجة الخلط اكثر اعلى من .05درجةمئوية والتي تؤثر على طبيعة الاسفلت وتعتبر غير امنة. طريقة السوبيربيف لحساب درجة الحدل والخلط تعتبر غير عملية للاسفلت المعدل.وجد ان هنال توافق جيد بين طريقة مارشال واللزوجة عالية القص . تم إجراء اختبار مارشال لدراسة الثبات ، التدفق ، والمعاملات الحجميةلمخاليط الأسفلت المعدلة للحصول على درجة حرارة الدمك التي تقابل الحد الأقصى من الاستقرار والكثافة القصوى. متوسط درجة حرارةالدمك عن طريق اختبار مارشال مماثل تقريبًا لطريقة اللزوجة العالية القص وأقل من طريقة السوبر بيف حيث يتراوح الانخفاض من .5إلىْ .0م ER -