TY - JOUR ID - TI - The Effect of Glass and Carbon Fibers and Powders Addition on the Sliding Wear Behavior of Unsaturated Polyester Resin تأثير إضافة ألياف ومساحيق الزجاج والكاربون على سلوك البلى الأنزلاقي لراتنج البولي استر غير المشبع AU - Edrees E. Ghadeer ادريس عيدان غدير AU - Ismail K. Al-Dahmashy اسماعيل خليل الدهمشي AU - Yahya I. Abdul-Rahman يحيى ابراهيم عبد الرحمن PY - 2019 VL - 28 IS - 1E SP - 73 EP - 84 JO - Rafidain journal of science مجلة علوم الرافدين SN - 16089391 AB - The current investigation is interested in studying the wear phenomenon for unsaturated polyester resin reinforced by a different weight fraction of glass and carbon fibers and powders. The prepared specimens were tested according to standard (ASTM-D5963) using a dvice pin-on-disk, at room temperature. The influence of wear parameter like, applied load, sliding speed on the wear rates were investigated. It was observed that the carbon and two types of glass fibers composite shows lower wear rates than the carbon and glass powders composites, under varying the loads and sliding speeds. In the case of sliding speed increased the results show that the increased of the weight fractions of carbon and glass powders will decrease the wear rates of composites prepared from this powders, while in the case of loading increase the wear rates increased when the weight fraction increased up to (4.16 Wt.%) for both carbon and glass powders.

يهتم بحثنا الحالي بدراسة آلية حدوث ظاهرة البلى لراتنج البولي أستر غير المشبع المقوى بكسور وزنية مختلفة بالياف ومساحيق الزجاج والكاربون. أختبرت العينات المحضرة وفقاً لنظام (ASTM-D5963) باستخدام جهاز المسمار على القرص، عند درجة حرارة الغرفة. تم حساب معدلات البلى تحت تاثير مَعْلَماتْ (متغيرات) البلى، كالحمل المطبق وسرعة الأنزلاق. حيث لوحظ ان متراكبات ألياف الكاربون والزجاج بنوعيه، أظهرت أقل معدلات البلى بالمقارنة مع متراكبات المساحيق الكاربونية والزجاجية، عند تغير كل من الاحمال وسرع الانزلاق. في حالة زيادة السرعة الانزلاقية، أظهرت النتائج أن زيادة الكسور الوزنية لمساحيق الزجاج والكاربون قلل من معدلات البلى للمتراكبات المحضرة من هذه المساحيق، أما في حالة زيادة الحمل، فان معدلات البلى ازدادت بزيادة الكسر ألوزني لأعلى من (4.16 Wt.%) لكل من مسحوق الزجاج والكاربون. ER -