TY - JOUR ID - TI - Effecting of Steel Fibers and Fly Ash on the Properties of Concrete تأثير األلياف الحديدية والرماد المتطاير على خصائص الخرسانة AU - Mazin B. Abdul-Rahman AU - Alya’a A. Ali AU - Amenah M. Younus PY - 2018 VL - 25 IS - 4 SP - 30 EP - 36 JO - Tikrit Journal of Engineering Sciences مجلة تكريت للعلوم الهندسية SN - 1813162X 23127589 AB - In this research, the effect of the addition of fly ash particles with different weight ratios of 15%, 20%, and 25% as well as the addition steel fibers with different volume fractions of 0.25%, 0.75%, and 1.25% on the mechanical properties of concrete (compressive strength and modulus of rupture) was studied. To carry out this research, ten concrete mixes were prepared, one of which is the reference normal concrete (without any additives), the others contain steel fibers and fly ash as additives with the mentioned volumetric and weight proportions. For each type of concrete mix, three standard 150×300 mm cylinders and three standard prisms100×100×500 mm were casted, water to cementing material ratio was fixed for all concrete mixes (W/cm = 0.435) and the superplasticizer was used with ratio of 0.98%-1.22% by weight of the cementitious material in mixtures that contain steel fibers and fly ash particles as a partial replacement of cement weight. The results showed that the addition of fly ash particles had little effect on the mechanical properties of normal concrete, while the steel fibers had the greatest effect. The highest increase in compressive strength and flexural strength compared with reference concrete was 61.60% and 78.84%, respectively in the volume fractions 1.25% of steel fiber.

في هذا البحث تم دراسة تأثير إضافة جزيئات الرماد المتطاير بنسب وزنية مختلفة (15، %20، %25%) وكذك إضافة األلياف الحديدية بنسب حجمية مختلفة (25.0% ،75.0%، 25.1%)على الخصائص الميكانيكية للخرسانة اإلعتيادية في االنضغاط واالنثناء . وإلجراء هذه الدراسة تم تحضير عشر خلطات خرسانية، واحدة منها للخرسانة االعتيادية المرجعية )الخالية من المضافات(، واالخرى تحتوي على مضافات األلياف الحديدية والرماد المتطاير وبالنسب الحجمية والوزنية المذكورة أعاله. لكل نوع من ( ملم، وثالثـة مواشير قياسـية أيضا 100×100×500 )ملم، وكانت نـسـبـة الـماء الى الســمنت ثابتة ً انواع الخلطات الخرسانية تم صب ثالثة اسطوانات قياسية )150×300( في الخلطات الخرسانية كافة ومساوية الى (435.0 الملدن الفائق بنسبة ستخدم (، وأ 98.0-1.22 )%من وزن المواد السمنتية للخلطات المعززة باأللياف الحديدية والتي تحتوي على جزيئات الرماد المتطاير كاستبدال جزئي من وزن السمنت. وقد أظهرت النتائج بان اضافة جزيئات الرماد المتطاير لها تأثير قليل على الخواص الميكانيكية للخرسانة االعتيادية ، في حين كان لاللياف الحديدية التأثير األكبر، إذ كانت أعلى نسبة زيادة في مقاومة االنضغاط ، ومقاومة االنثناء بالمقارنة مع الخرسانة المرجعية هي )60.61 )% و )84.78 )%على التوالي عند النسبة الحجمية )25.1 )%لاللياف الحديدية. ER -