TY - JOUR ID - TI - Performance Comparison between Recycled Single Stage and Double Stage Hydrocyclones مقارنة الاداء بين الهيدروسايكلون احادي المرحلة بعد تدويرالناتج فيه لمرة واحدة وبين الهايدروسايكلون ثنائي المرحلة AU - Mohannad A. Raheem مهند عبد الستار رحيم AU - Raghad F. Qassim رغد فريد قاسم PY - 2020 VL - 21 IS - 3 SP - 51 EP - 55 JO - Iraqi Journal of Chemical and Petroleum Engineering المجلة العراقية للهندسة الكيمياوية وهندسة النفط SN - 19974884 26180707 AB - This research presents a comparison of performance between recycled single stage and double stage hydrocyclones in separating water from water/kerosene emulsion. The comparison included several factors such as: inlet flow rate (3,5,7,9, and 11 L/min), water feed concentration (5% and 15% by volume), and split ratio (0.1 and 0.9). The comparison extended to include the recycle operation; once and twice recycles. The results showed that increasing flow rate as well as the split ratio enhancing the separation efficiency for the two modes of operation. On the contrary, reducing the feed concentration gave high efficiencies for the modes. The operation with two cycles was more efficient than one cycle. The maximum obtained efficiencies were 97% and 97.5% at 5% concentration, 11 L/min, and 0.9 split ratio for twice recycled single stage and double stage hydrocyclones, respectively. The pressure drop was the same for the two modes of operation. It was concluded that using recycled single stage hydrocyclone was more economical since it reduced the cost of additional hydrocyclone.

يقدم هذا البحث مقارنة الأداء بين الهيدروسايكلون ذي المرحلة الواحدة بعد اعادة تدوير الناتج منه لمرة واحدة فقط وبين الهيدروسايكلون ثنائي المرحلة في فصل الماء من مستحلب الماء / الكيروسين. تضمنت المقارنة عدة عوامل مثل: معدل الجريان الداخل (11،9،7،5،3 لتردقيقة)وتركيزالماء الداخل(5 ٪ و 15 ٪ من حيث الحجم) ، ونسبة الفصل (0.1 و 0.9). أظهرت النتائج أن زيادة معدل الجريان وكذلك نسبة الفصل تزيد من كفاءة الفصل لكلا الطريقتين. كذلك أعطى تقليل تركيز الماء الداخل كفاءة عالية لكلى الحالتين ايظا. كانت العملية مع اعادة التدويرللهايدروسايكلون أكثر كفاءة من دورة واحدة لنفس الهيدروسايكلون. كانت أقصى قدر من الكفاءة التي تم الحصول عليها 97 ٪ و 97.5 ٪ بتركيز 5 ٪ ، 11 لتر / دقيقة ، و 0.9 نسبة الفصل للهايدروسايكلون ذي المرحلة الواحدة بعد اعادة التدوير والهايدروسايكلون ثنائي المرحلة على التوالي. كان انخفاض الضغط هو نفسه بالنسبة لطريقتي التشغيل. وخلصنا إلى أن استخدام الهايدروسايكلون أحادي المرحلة المعاد تدويره كان أكثر اقتصادا لأنه خفض تكلفة الهايدروسايكلون الإضافي. ER -