TY - JOUR ID - TI - Performance of Gas Induction in a Dual – ImpellerAgitated Bioreactor اداء المفاعلات الحيوية ذات الخلاطات المزدوجة الساحبة للهواء AU - Safa Abid Al-Rassul صفاء عبد الرسول AU - Hassanin Ali Hussen حسنين علي حسين AU - Alaa K. Mohammed علاء كريم محمد PY - 2008 VL - 4 IS - 4 SP - 1 EP - 8 JO - Al-Khwarizmi Engineering Journal مجلة الخوارزمي الهندسية SN - 18181171 23120789 AB - The rate of gas induction was measured in gas-inducing type mechanically agitated contactors provided with two impellers. A reactor of 0.5 m i.d. was used with a working capacity of 60 liters of liquid. Tap water was used as the liquid phase, and air was used as the gas phase. The bioreactor mixing system consists of two equal diameter stirrers; the top impeller is shrouded-disk/curved-blade turbine with six evacuated bending blades, while the bottom impeller was disk turbine. The impeller speed was varied in the range of 50 to 800 rpm. The ratio of impeller diameter to tank diameter (D/T) and the submergence (S) of upper impeller from the top were varied. The effects of clearance of lower impeller from the tank bottom (C2) and the impeller spacing (C3, distance between the two impellers) were also varied over a wide range. Rate of gas induction (Q) was measured for all these combinations. It was found that the rate of gas induction increases with both decreasing in submergence and increasing in the stirrer diameter. While it decreases with both increasing the impeller spacing and the clearance from the bottom

تم قياس معدل سحب الهواء في المفاعلات الحيوية ذات الخلاطات المزدوجة الساحبة للهواء. استخدم مفاعل ذو قطر 0.5 م وسعة 60 لتر. استخدم الماء كوسط سائل والهواء كوسط غاز. يتكون نظام الخلط في المفاعل من خلاطين متساويين في القطر: الخلاط الاعلى من نوع الريش الانبوبية الساحبة للهواء (shrouded disk/curved-blade turbine) والخلاط الاسفل من نوع القرص التوربيني(disk turbine). المتغيرات التي تم دراستها في هذا البحث هي :سرعة دوران الخلاط بحدود 500 – 800 دورة/دقيقة ، نسبة قطر الخلاط الى قطر المفاعل ، عمق الخلاط الاعلى عن سطح السائل (submergence )، المسافة بين الخلاطين (Clearance ) ، بعد الخلاط الاسفل عن قعر المفاعل. وجد ان معدل سحب الهواء يزداد بزيادة قطر الخلاط ونقصان عمق الخلاط عن السطح العلوي للسائل، بينما يقل معدل السحب بزيادة المسافة بين الخلاطين وزيادة المسافة بين قعرالمفاعل والخلاط السفلي. ER -