TY - JOUR ID - TI - Experimental Study and Theoretical Model Described Transition Regime Parameters and Hydrodynamic Parameters in a Gas-Liquid Dispersion Column دراسه عمليه وموديل نظري يصفان القيمه المحدده للمنطقه الانتقاليه والقيمه المحدده للخواص الهيدروديناميكيه في عمود التشتييت من غاز- سائل AU - Fadi Z. Hanna PY - 2010 VL - 28 IS - 9 SP - 1778 EP - 1801 JO - Engineering and Technology Journal مجلة الهندسة والتكنولوجيا SN - 16816900 24120758 AB - Experimental study of total gas hold-up, bubble diameters and rise velocity ofthe swarm of bubbles, and regime transition point in dispersion column. Theexperimental runs were carried out in two perspex columns of 7.5 cm and 15 cm insidediameter. The present work investigated the effect of two system of two-liquid phase(air-water, and air-aqueous-n-propanol solution) in the range (0.05-0.7Wt%),superficial air velocity in the range (0.025-0.3 cm/s) and two air distributor plates of1.5 mm diameter holes (i.d.= 7.5 cm, holes=36 and free area=1.4%, and i.d.= 15 cmholes=121 and free area=1.2%). In this paper, a Krishna et al., 1999 model has beenimproved, and the combination of this improved model with derived drift flux modelhave been described the hydrodynamics of dispersion column operating inhomogeneous and heterogeneous flow regimes (i.e. transition regime parameterest ransand Utrans ). Photographic technique was used by taking three pictures in different view(different angle) of the dispersion column, to measure the hydrodynamic parameters.From the experimental data, it was found that the addition of a small amount of npentanolto distilled water and varying dispersion column diameter, is the main factorthat affects, the transition flow regime. Also the experimental results show that thevalues of total gas hold-up for air-aqueous n-pentanol solution system are greater thanthe values for air-water system, but the values of total gas hold-up decrease withdispersion column diameter for two systems.The experimental data show that the values of total gas hold-up and superficial airvelocity at transition regime varied with the weight percent of n-pentanol by fitting ofsecond order polynomial regressions for the two dispersion column diameters:

لقد تم اجراء دراسه عمليه لكميه الغاز المحتجز الكلي وقطر الفقاعات والسرعه الصعوديه لحشدمن الفقاعات ونقطه حدوث المنطقه الانتقاليه في عمود تشتيت. وقد تمت التجارب باستخدام عمودين تشتيت بقطر داخلي 7,5 و 15 سم. تم دراسة تاثير نظامين هما (هواء-ماء و هواء- محلول مائي0,7 %) وسرعة الهواء الظاهرية التي - للبنتانول- اعتيادي بتراكيز وزنيه مختلفه ضمن المدى ( 0,050,3 م/ثانيه) باستخدام موزعين للهواء بقطر ثقب 1,5 ملم (قطر عمود= 7,5 - تراوحة بين ( 0,025سم، عدد الثقوب= 36 ومساحه التثقيب= 1,4 % وقطر عمود= 15 سم، عدد الثقوب= 121 ومساحهوتم ربط هذا الموديل (Krishna et al., التثقيب= 1,2 %).في هذا البحث تم تطوير موديل ل( 1999لوصف الخواص الهيدروديناميكيه لعمود التشتييت يعمل (Drift Flux) المطور مع اشتقاق لموديلعند منطقه الجريان المتجانس ومنطقه الجريان الغير متجانس (القيمه المحدده لمنطقه الجرياناستخدمت تقنيه التصوير باخذ ثلاث صور بمشاهد مختلفه (زوايا مختلفه) .( Utrans و etrans الانتقاليهلعمود التشتييت، من خلال هذه الصور تم حساب الخواص الهيدروديناميكيه. من خلال النتائجالعمليه، تم الوصول الى انه اضافه كميه قليله من البنتانول- الاعتيادي للماء المقطر وتغيير قطرعمود التشتييت هما العاملان الرئيسيان المؤثران على منطقه الجريان الانتقاليه. وكذلك اظهرتالنتائج العمليه ان قيم كميه الغاز المحتجز الكلي لنظام هواء-محلول مائي للبنتانول-الاعتيادي اكبرمن نضيراتها لنظام هواء-ماء، لكن قيم كميه الغاز المحتجز تقل مع زياده قطر عمود التشتييتللنظامين. بينت النتائج العمليه ان قيم كميه الغاز المحتجز الكلي وسرعه الهواء الظاهريه عند منطقهالجريان الانتقاليه تتغير مع النسبه الوزنيه للبنتانول-الاعتيادي طبقا لعلاقه متعدده الحدود اظهرتنتائج جيده جدا لعمودي التشتييت: ER -