TY - JOUR ID - TI - Effect of Rare Earth Oxides (Y2O3, Nd2O3) on Oxidation Kinetics of Al-Li base alloy تأثير اكاسيد العناصر النادرة ( Nd2O3 و Y2O3 ) على السلوك الكيناتيكي للتأكسد لسبيكة المنيوم –ليثيوم AU - Dr. Muna K. Abbass منى خضير عباس PY - 2007 VL - 10 IS - 1 SP - 37 EP - 52 JO - Al-Nahrain Journal for Engineering Sciences مجلة النهرين للعلوم الهندسية SN - 25219154 25219162 AB - The oxidation of Al-Li base alloy containing smallamounts of rare earth (RE) oxides such as Y2O3 andNd2O3 particles has been studied at temperaturesbetween 300°Cand 550°C. The lithium is selectivelyoxidized in Al-Li alloys and the parabolic rateconstants for the growth of the resulting oxides layerLi2O, LiAl5O8, Li2CO3 and Li5AlO4 are about anorder of magnitude higher than those for growth ofoxides on alloy (Al-Li) with RE oxides. Alloys usedin this study were prepared by melting and casting ina permanent steel mould under controlledatmosphere.It was found that 0.2%Y2O3 containing alloyspossess the lowest oxidation rate and show greatimprovements in oxidation resistance compared tothe base alloy.Oxides found on base alloy are subjected tocracking and spalling during thermal shock at hightemperature i.e. 500°Cand 550°C. Identification ofoxidation kinetics was carried out by using weightgain measurements while scanning electronmicroscopy (SEM) and x-ray diffraction analysiswere used for microstructural morphologies andphase identification of the oxide scales. The weightgain measurement results suggest that the oxidationkinetic of all studied alloys follows the parabolic lawin most experimental tests under the differenttemperatures except at 300°C oxidation kineticfollows almost a logarithmic rate law.

تم دراسة التأكسد لسبيكة أساس( المنيوم- ليثيوم ) تحتوي على كميات قليلة من الدقائق الاوكسيدية من العناصر النادرة (Nd2O3 و Y2O3) في درجات حرارية (300°C-550°C ). وتم تحضيرهذه السبائك بعملية الصهر والصب في قوالب فولاذية وتحت أجواء مسيطر عليها. أن عنصر الليثيوم يتأكسد انتقائيا مكونا مجموعة من الآكاسيد Li2O , LiAl5O8 , Li2CO3 وLi5AlO4 وكانت قيم ثابت معدل التأكسد القطع المكافئ (Kp) للسبيكة الاساس أعلى مما في حالة السبائك الاخرى الحاوية على أكاسيد Nd2O3 و Y2O3تحت ظروف مماثلة. وجد ان السبيكة الحاوية على دقائق الياتيريا ( Y2O3 0.2%) تمتلك أقل معدل تأكسد اي اعلى مقاومة تأكسد مقارنة مع السبائك الاخرى. وكذلك وجد ان الاكاسيد المتكونة على االسبيكة الاساس ( Al-Li ) تتعرض الى التشقق والتقشر عند أجراء الصدمة الحرارية في درجة حرارة 500°C و550°C بعد مرور 50 ساعة من التأكسد. تم التعرف على السلوك الكيناتيكي العام للتأكسد بأجراء قياسات الوزن المكتسب للسبائك عند التأكسد الايزوثرمي في الهواء الجاف وكذلك اجراء فحص حيود الاشعة السينية. وأستخدام المجهر الالكتروني الماسح لدراسة طوبوغرافية وبنية الطبقات الاوكسيدية المتكونة على السطح, وقد أظهرت نتائج التأكسد ان كل السبائك تخضع لقانون القطع المكافئ في جميع الدرجات الحرارية المستخدمة في البحث ما عدا الدرجة الحرارية 300°C حيث تخضع تقربيا للقانون اللوغارتمي. ER -