TY - JOUR ID - TI - Numerical and Experimental Study on the PressureDistribution ina Volute of High-Speed Centrifugal Fan with Impeller- Volute interaction(English) دراسة نظرية وعملية علر توزيع الضغط للمجرى الحلزوني لمروحة طرد مركزية ذات سرعة عالية مع تداخل الدافعة الحلزونية AU - Dr.Muthana K. Aldoory د. مثنى خالص الدوري AU - Ahmed A. Ali أحمد علي PY - 2012 VL - 20 IS - 5 SP - 69 EP - 91 JO - AL-Rafidain Engineering Journal (AREJ) مجلة هندسة الرافدين SN - 18130526 22201270 AB - ABSTRACT This paper shows a numerical simulation in capturing the dynamic and static pressure effects inside a centrifugal fan due to the impeller-volute interaction.The fan used in this study is a single-stage machine with an unshrouded impeller and external volute.Three volute tongue designs were investigated. Volute C had a full tongue and did not allow any flow recirculation. Volute B had a reduced tongue length thereby opening the recirculation port. Finally the tongue of volute A had a rounded leading edge to make it less sensitive to off-design flow conditions. For the numerical simulation, the viscous Navier-Stokes equations are handled with unstructured grid and the relative reference frames technique is applied to take into account the impeller-volute interaction. The data obtained allow the analysis of the main phenomena existent in these fans, such as: pressure changes in the volute for different flow rates and the secondary flow generated in the volute due to the width change between the impeller and the volute. Numerical results are compared with the experimental pressure data measured in the volute and agreement is found show that at low flow rates ,the volute decelerates the airflow leading to an increase in pressure throw the volute. At these low flow rates separation or flow unsteadiness can occur from the underside of the tongue and the strength of the instability increased when the mass flow rate was reduced further. The pressure fluctuation for various mass flow rates is a non-periodical nature and it is manifest as the broad band components in higher level of random frequency (up to nearly 500 Hz).This investigation concentrates on the measurement of the flow characteristic in the volute casing and the volute tongue configuration.KEYWORDS Flow in volute, Centrifugal fan, volute tongue

الخلاصةيستعرض البحث التمثل العددي لحساب ضغط الهواء الديناميكي و الساكن في داخل المجمع (volute) لدافعة الهواء كنتيجة للتأثير المتبادل بين المروحة (impeller) و المجمع. دافعة الهواء المستخدمة في هذا الدراسة ذات مرحلة واحدة و المروحة من النوع المفتوح و المجمع خارجي. تم دراسة ثلاث أنواع من نتوء لسان (tongue) المجمع ، نوعC: لسان بطول كامل، لايسمح للهواء بالدوران في داخل المجمع.نوع B: لسان بطول غير كامل، يسمح لبعض الهواء بالدوران داخل المجمع ونوع A : لسان بنهاية مستديرة و حسب التصميم الأساسي لدافعة الهواء ليكون أقل حساسية للتشغيل خارج ظروف التصميم.لغرض تمثيل الجريان استخدمت معادلات Navier- Stokes مع الأخذ بنظر الاعتبار لزوجة الهواء. الوصف الشبكي للمجمع من نوع غير المهيكل و ذو إطار مرجعي نسبي عند الأخذ بنظر الاعتبار للتأثير المتبادل ما بين المروحة و المجمع على خصائص الجريان. البيانات المستحصلة من هذا التمثيل استخدمت لتحليل ظاهرة طبيعة الجريان من حيث تغيير الضغط في المجمع كنتيجة لتغيير معدل جريان الهواء من الدافعة. استدلت النتائج إلى حدوث جريان ثانوي في المجمع بسبب وجود المسافة الفاصلة بين المروحة و المجمع. تم مقارنة النتائج العددية مع نتائج التجارب العملية و حصول التوافق بينهما. وقد بينت التجارب كذلك ان المجمع يعمل على تباطأ سرعة الهواء و زيادة في الضغط. عند معدلات الجريان الواطئة ويحصل عدم استقرار للجريان تحت منطقة نتوء اللسان و يزداد عدم الاستقرار عند الاستمرار في خفض معدلات الجريان. التذبذب في ضغط الهواء في المجمع ذو طبيعة عشوائية و يغطي طيف التذبذب مدى واسع و لغاية Hz 500 . ER -