TY - JOUR ID - TI - Corrosion Behavior for Al-Cu-Mg Alloy by Addition SiO2 Particles in Seawater السلوك التأكلي لسبیكة المنیوم-نحاس- معنیسیوم باضافة دقائق السلیكا في ماء البحر AU - Rana A. Majed AU - Mervit Mahdi AU - Hanaa A. Al-Kaisy AU - Saja A. Abdul Maged PY - 2014 VL - 32 IS - 2 Part (A) Engineering SP - 354 EP - 364 JO - Engineering and Technology Journal مجلة الهندسة والتكنولوجيا SN - 16816900 24120758 AB - This work involves studying the effect of adding SiO2 particles on corrosion behavior of Al-Cu-Mg alloy in 3.5% NaCl solution at room temperature using polarization method at scan rate 3 mV.sec-1. According to potentiodynamic polarization test, the results of corrosion rate indicate that Al-Cu-Mg composites (1, 2, 3 wt% SiO2) gave decreasing in corrosion rate compared with Al-Cu-Mg alloy due to the covering the anodic sites for alloy by SiO2 particles and enhancing the passivity of surface and reducing the dissolution of aluminum. The cathodic Tafel slope (bc) were decreased after adding SiO2, while the anodic Tafel slopes (ba) were increased. It is inferred that the rate of change of current with change of potential was smaller during anodic polarization than that during cathodic polarization. Cyclic polarization measurements were carried out to estimate the pitting resistance of Al-Cu-Mg composites. The results show that a stable oxide film is formed during the forward scan on the surface of composites; also the hysteresis loop disappears, especially for composite with 3 wt%SiO2.

تتضمن هذه الدراسة تأثير دقائق السليكا على السلوك التأكلي لسبيكة المنيوم – نحاس – مغنيسيوم في محلول كلوريد الصوديوم بنسبة 3.5% عند درجة حرارة الغرفة باستخدام طريقة المجهاد الساكن عند معدل سرعة مسح مساوية لـ 3 ملي فولت لكل ثانية، ووفقاً لنتائج اختبار الاستقطاب الخطي فان معدل التأكل للمواد المتراكبة ذات اساس معدني من سبيكة الالمنيوم مع دقائق السليكا بنسب وزنية ثلاثة 1 و 2 و3 % قد اصبح اقل مقارنة بمعدل التأكل للسبيكة الاساس وذلك بسبب تغطية المواقع الانودية للسبيكة بدقائق السليكا وتعزيز سلبية السطح وتقليل ذوبان الالمنيوم من السبيكة. لوحظ نقصان في قيم ميل تافل الكاثودي بعد اضافة دقائق السليكا، بينما لوحظ زيادة في قيم ميل تافل الانودي مبيناً ان التغير الحاصل في التيار مع تغير الجهد كان اقل خلال الاستقطاب الانودي مما في الاستقطاب الكاثودي. وقد بينت نتائج قياس الاستقطاب الحلقي استقرارية غشاء السلبية المتكون في حالة المواد المتراكبة اضافة الى اختفاء الحلقة الهستيرية وخصوصاً في حالة اضافة (3 wt%) من السليكا. ER -