TY - JOUR ID - TI - FACTORS AFFECTING AERATION IN FERMENTORS WITH AIR- SUCTION TYPE IMPELLER العوامل المؤثرة في عملية التهوية للمخمرات ذات الخلاطات الساحبة للهواء AU - علاء كريم محمد PY - 2008 VL - 7 IS - 2 SP - 239 EP - 249 JO - Iraqi Journal of Biotechnology المجلة العراقية للتقانات الحياتية SN - 18154794 25207245 AB - The rate of gas induction was measured in gas-inducing type mechanically agitated contactors provided with two impellers. A reactor of 0.5 m i.d. was used with a working capacity of 60 liters of liquid. Tap water was used as the liquid phase, and air was used as the gas phase. The bioreactor mixing system consists of two equal diameter stirrers; the top impeller is shrouded-disk/curved-blade turbine with six evacuated bending blades, while the bottom impeller was disk turbine. The impeller speed was varied in the range of 50 to 800 rpm. The ratio of impeller diameter to tank diameter (D/T) and the submergence (S) of upper impeller from the top were varied. The effects of clearance of lower impeller from the tank bottom (C2) and the impeller spacing (C3, distance between the two impellers) were also varied over a wide range. Rate of gas induction (Q) was measured for all these combinations. It was found that the rate of gas induction increases with an increase in the impeller diameter and with a decrease in the impeller clearance, while it decreases as the liquid submergence increases and as the clearance from bottom increases.

تم قياس معدل سحب الهواء في المفاعلات الحيوية ذات الخلاطات المزدوجة الساحبة للهواء. استخدم مفاعل ذو قطر 0.5 م وسعة 60 لتر. كما استخدم الماء كوسط سائل والهواء كوسط غاز. يتكون نظام الخلط في المفاعل من خلاطين متساويين في القطر :الخلاط الاعلى من نوع الريش الانبوبية الساحبة للهواء shrouded disk/curved-blade turbine والخلاط الاسفل من نوع القرص التوربيني disk turbine. المتغيرات التي تم دراستها في هذا البحث هي :سرعة دوران الخلاط بحدود 500 – 800 دورة/دقيقة ونسبة قطر الخلاط الى قطر المفاعل و عمق الخلاط الاعلى عن سطح السائل submergence والمسافة بين الخلاطين Clearance وبعد الخلاط الاسفل عن قعر المفاعل. وجد ان معدل سحب الهواء يزداد بزيادة قطر الخلاط ونقصان عمق الخلاط عن السطح العلوي للسائل، بينما يقل معدل السحب بزيادة المسافة بين الخلاطين وزيادة المسافة بين قعرالمفاعل والخلاط السفلي. ER -